Bell v. Consolidated Gas, Electric Light, Heat & Power Co.

The action is for damages for alleged negligence in causing the death of the plaintiff’s intestate. The deceased was in the employ of the defendant as a fireman, and at the time of the accident which caused his death had been in such service about seven years. The defendant had in its power house a horizontal tubular boiler of the Babcock & Wilcox make. In this style of boiler the water is in the tubes. At the ends of the tubes there are caps fastened to the tubes, each by a bolt and nut, so that they, may be removed, and the tubes opened whenever desired. From time to time it became necessary to clean the boiler, in which case the caps were removed. The frequency of cleaning the boiler varies according to its use. Some boilers have to be cleaned as often as once a month; others not oftener than once a year. A day or two before the accident, the defendant’s engineer, who had general charge of running the engine in the power house, had the boiler cleaned. After this work was done, the deceased, under the direction of the engineer, replaced the caps. Water was run into the boiler, and the fire started. The engineer testifies that he then told the deceased to go behind the boiler, and see if there were any leaks. A workman, one Wolvern, gave evidence that the. engineer directed the deceased to go under the boiler to the mud drum. The deceased went under the boiler, and while there one of the caps blew off, thus permitting the steam to escape. Deceased was so injured by the escaping steam that he died on the following day. It was conceded on the trial that .the boiler was of proper design and style, and that its parts were in good condition, but evidence was given by experts for the plaintiff tending to show that the replacing and fastening of the caps was a work requiring considerable skill; that the bolt, being in a horizontal position, its weight tended to make it sag, and that it was a work of great difficulty to have the threads on the bolt fit exactly into the threads of the nut; and that, if the bolt was not exactly in the proper place, the torsional strain in screwing it up and tightening the cap was liable to injure and weaken the bolt. They testified that for this reason, whenever the caps were taken off and replaced, the boiler should be subjected to a hydrostatic test before it was attempted to make steam in it; that this test would show whether the caps were on tight, and whether the bolts had been weakened. No such test was made on this occasion, and the failure to make the test was the charge of negligence which was submitted to the jury. The learned court charged the jury that they should determine as a matter of fact whether -the defendant should have taken the precaution of having a hydrostatic test, and that, if they found such • precaution should have been taken, and, if taken, it would have disclosed the defective condition of the bolt, which led to the accident, they might find that the defendant was negligent.

It is the duty of a master to use reasonable care to provide for his servant a safe place to work and safe appliances to work with. The case before us, however, is neither one of an unsafe place nor that of a defective appliance. The boiler is conceded to have been suitable in design, and in good condition. The theory of the plaintiff is that the accident was occasioned by the injury to the bolt, which

But, granting that a hydrostatic test should have been made, the question then arises, whose fault was it that the test was not had? It is undoubtedly the duty of the master, besides providing a safe place and safe appliances for his servants, to establish reasonable rules for the conduct of Ms business, so as to protect his servants from unnecessary danger (Abel v. Canal Co., 128 N. Y. 662 , 28 N. E. 663 ); but tMs principle must be applied with reference to the character of the work prosecuted, and with reference to the known duties of the employés. When a master employs a competent engineer to run an engine, he is no more required to give him instructions as to the rudiments and common knowledge of his trade than he is a teamster or carpenter. Of course, this is in the absence of knowledge of negligence or incompetence on the part of the employé. Indeed, I think there may be cases in which the master is entitled to rely upon the superior knowledge of his servants in the particular work to be done, and is under no obligation to promulgate rules at all. If a master is conducting a large factory, he is bound either to' familiarize himself with the conduct of the work, or obtain a superintendent for that purpose, who would stand in his place. In the operation of a factory, rules might well be necessary to protect the workmen, and for the failure by the master or Ms superintendent to promulgate suitable rules the master would be liable. But if a master is conducting a warehouse business, in which it is convenient or necessary to have steam power for hoisting purposes, and trucks and teams for transporting goods, I think that he is not bound to master the operation of the steam engine, or the management and care of horses, and that he has discharged Ms duty to his employés, so far as the conduct of the business in these respects is concerned "(I do not speak of the plant or appliances themselves), when he has secured á competent engineer to take charge of the engine, and a competent teamster as foreman of Ms stable. If it is a part of the ordinary duty of the engineer, after removing and replacing the caps on a tubular boiler, to test it hydrostatically, the failure to do so in this case was the negligence of a fellow servant. Webber v. Piper, supra; Cullen v. Norton, 126 N. Y. 1 , 26 N. E. 905 . On tMs question the evidence is extremely meager, but what there is of it tends to support the view that it was the duty of the engineer to* make the test. There is not a word in the testimony to the contrary. There is nothing to show

In our opinion, the objection to the question put to the witness Beckman, as to the practice of subjecting boilers to a hydrostatic test in the city of Newburgh, was improperly sustained. The practice, if proved, would not have been conclusive on the question of the necessity of making the test, but it was competent evidence. The defendant was not required to furnish the best or most modern appliances to its employés, nor conduct its business in the latest or most approved manner. It was sufficient if it conducted its business in .a reasonably safe manner, and in accordance with common custom. The judgment and order appealed from should be reversed, and a new trial granted; costs to abide the event.

Judgment and order reversed, and new trial granted; costs to abide the event. All concur.